- Manuals
- Brands
- Suburban Manuals
- Water Heater
- SW6DEL
- Installation and operation manual
Direct vent gas water heater
Hide thumbs Also See for SW6DEL:
- Installation and operation manual (10 pages) ,
- Service training manual (44 pages)
-
- Contents
- Table of Contents
- Bookmarks
Table of Contents
-
Installation Requirements
-
Installation Instructions
-
Installation Using Hinged Door
-
Water Heater as View from Inside R.V.
-
Sw6Del
-
Making Water Connections
-
Making Gas Connections
-
High Altitude Deration
- Making Electrical Connections 12 Volts D.C.
-
Maintenance
- Making Electrical Connections 120 Volts A.C.
-
Safety Warnings
- Thermostat and Manual Reset
-
Anode Protection
-
Pressure Relief Valve
-
Draining and Storage Instructions
-
Removing Water Heater
-
For Your Safety Read before Operating
-
Water Weeping or Dripping from Pressure Relief Valve
-
Odor from Hot Water System
-
What to Do if You Smell Gas
- Operating Instructions
-
To Turn off Water Heater
- Parts Illustration and Replacement Parts List
Advertisem*nt
Quick Links
- 1 Making Electrical Connections 12 Volts D.C.
- 2 Making Electrical Connections 120 Volts A.C.
- 3 Thermostat and Manual Reset
- 4 Operating Instructions
- 5 Parts Illustration and Replacement Parts List
- Download this manual
See also: Service Training Manual
Sw6Del • SW10DEL • SW12DEL • SW16DEL
! DO NOT TRY TO LIGHT ANY APPLIANCE.
! DO NOT TOUCH ANY ELECTRIC SWITCH: DO NOT USE ANY PHONE IN YOUR
VEHICLE.
! IMMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR'S PHONE.
FOLLOW THE GAS SUPPLIER'S INSTRUCTIONS.
IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE
!
DEPARTMENT.
DRAIN HEATER IF SUBJECT TO FREEZING TEMPERATURES.
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE
OR MAINTENANCE CAN CAUSE INJURY OR PROPERTY DAMAGE. REFER TO
THIS MANUAL. FOR ASSISTANCE OR ADDITIONAL INFORMATION, CONSULT A
QUALIFIED INSTALLER, SERVICE AGENCY OR THE GAS SUPPLIER.
DO NOT STORE OR USE GASOLINE OR OTHER COMBUSTIBLE MATERIALS OR
LIQUIDS NEAR OR ADJACENT TO THIS HEATER OR ANY OTHER APPLIANCE. THIS
APPLIANCE SHALL NOT BE INSTALLED IN ANY LOCATION WHERE FLAMMABLE
LIQUIDS OR VAPORS ARE LIKELY TO BE PRESENT.
INSTALLER: AFFIX THESE INSTRUCTIONS TO OR ADJACENT TO WATER HEATER.
OWNER: RETAIN THESE INSTRUCTIONS AND WARRANTY FOR FUTURE REFERENCE.
ALL TECHNICAL AND WARRANTY QUESTIONS SHOULD BE DIRECTED TO THE COMPANY
LISTED ON THE WARRANTY, OR RATING PLATE WHICH CAME WITH YOUR WATER HEATER.
Part Number 204539
3-24-09
INSTALLATION AND OPERATION
MANUAL
DIRECT VENT
GAS WATER HEATER
MODELS
FOR INSTALLATION IN RECREATIONAL
VEHICLES AND MOBILE HOUSING
FOR YOUR SAFETY
What To Do If You Smell Gas
FREEZE WARNING
FOR YOUR SAFETY
AN ODORANT IS ADDED TO THE GAS USED BY THIS WATER HEATER.
SUBURBAN MANUFACTURING COMPANY
676 Broadway Street
Dayton, Tennessee 37321
423-775-2131
www.rvcomfort.com
Advertisem*nt
Table of Contents
Related Manuals for Suburban SW6DEL
-
Water Heater Suburban SW10P Service Training Manual
(44 pages)
-
Water Heater Suburban SWGDEL Installation And Operation Manual
Direct vent gas water heater (10 pages)
-
Water Heater Suburban SW4DEL Installation And Operation Manual
(20 pages)
-
Water Heater Suburban SW12D Installation And Operation Manual
Direct vent gas water heater (13 pages)
-
Water Heater Suburban SW10D Installation And Operation Manual
Direct vent gas water heater direct spark ignition (dsi) (24 pages)
-
Water Heater Suburban SW10D Installation And Operation Manual
Direct vent gas water heater direct spark ignition (dsi) (13 pages)
-
Water Heater Suburban SW10DM Installation And Operation Manual
(24 pages)
-
Water Heater Suburban SW12D Installation And Operation Manual
Direct vent gas water heater direct spark ignition (dsi) for installation in recreational vehicles and mobile housing (7 pages)
-
Water Heater Suburban SW3P Service Manual
(23 pages)
-
Water Heater Suburban SW3P Service Manual
(24 pages)
-
Water Heater Suburban SW3P Service Manual
(26 pages)
-
Water Heater Suburban SW6D Installation And Operation Manual
Direct vent gas water heater for installation in recreational vehicles and mobile housing (13 pages)
-
Water Heater Suburban SW10D Installation And Operation Manual
Direct vent gas water heater direct spark ignition (dsi) (13 pages)
-
Water Heater Suburban SW10D Installation And Operation Manual
Direct vent gas water heater direct spark ignition dsi (7 pages)
-
Water Heater Suburban SW12D Installation And Operation Manual
Direct vent gas water heater direct spark ignition (dsi) (6 pages)
-
Water Heater Suburban SW4DRA Operating, Installation And Service Manual
Gas hot water storage heater (12 pages)
Summary of Contents for Suburban SW6DEL
- Page 1 INSTALLATION AND OPERATION MANUAL DIRECT VENT GAS WATER HEATER MODELS SW6DEL • SW10DEL • SW12DEL • SW16DEL FOR INSTALLATION IN RECREATIONAL VEHICLES AND MOBILE HOUSING FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS ! DO NOT TRY TO LIGHT ANY APPLIANCE.
-
Page 2: Installation Requirements
Figure 1 SW6DEL; Figure1A SW10DEL/ SW12DEL/SW16DEL. Maintain inside dimensions listed below. Do not install on K. The module board on models SW6DEL, is not secured to the water heater. carpet unless the carpet is covered by a metal or wood shield covering the entire It is to be permanently mounted by the installer. - Page 3 INNER COACH WALL INNER COACH WALL FRAMING OUTER COACH WALL FRAMING OUTER COACH WALL A=12 3/4"+1/8"-0" FLOORING FLOORING B=12 3/4"+1/8"-0" A = 16 3/8"±1/16" B = 16 3/8"±1/16" Figure 1 Figure 1A WATER HEATER AS VIEW FROM INSIDE R.V. FRAMED OPENING FLOOR SECURE CHOCKS, ONE ON EACH SIDE, TIGHTLY AGAINST WATER HEATER JACKET AND FASTEN TO VEHICLE FLOOR TO PREVENT MOVEMENT.
- Page 4 SW6DEL Figure 2 SW10DEL SW12DEL SW16DEL Figure 2A...
- Page 5 AND TUBING) ALL AROUND AIR TIGHT Consult with the local gas company, your dealer, an RV service agency or Suburban Manufacturing Company for proper derating of the unit. Change- Figure 5 out of the orifice (derating) should be done by the dealer or a qualified service...
-
Page 6: Electrical Connections
MAKING ELECTRICAL CONNECTIONS 12 VOLTS D.C. A. Refer to Figure 2 for location of D.C. junction box SW6DEL. B. The electrical connections must be made in accordance with local codes and regulations. In the absence of local codes and regulations, refer to the latest edition of the National Electrical Code NFPA 70. -
Page 7: Safety Warnings
SAFETY WARNINGS THERMOSTAT AND MANUAL RESET MODELS: SW6DEL, SW10DEL, SW12DEL, SW16DEL (See Figure 9) WARNING! It is imperative that the water heater tank be filled with water before operating the water heater. Operation of the water heater without The model water heaters listed above are equipped with a high temperature limit water in the tank may result in damage to the tank and/or controls. -
Page 8: Pressure Relief Valve
of the anode rod. Proper application of a thread sealant will not interfere with the DRAINING AND STORAGE INSTRUCTIONS anode’s tank protection. If RV is to be stored during winter months, the water heater must be drained to prevent damage from freezing. Operating the water heater without proper anode protection will decrease tank life and will void your warranty on the tank. - Page 9 WARNING: Before operating water heater, be sure tank is filled with water. See “Safety Warnings”. A. This appliance does not have a pilot. It is equipped with an ignition device which automatically lights the burner. Do not try to light the burner by hand. B.
-
Page 10: Replacement Parts List
2. Part Description 3. Model No. and Serial No. of your Heater 4. Number of Parts Required PARTS LIST FOR MODELS (Figure 12 - SW6DEL • Figure 13 SW10DEL/SW12DEL, SW16DEL) NOTE: Part numbers are common to all models unless noted. Item Description Part Number Module Board ........................ - Page 11 SW6DEL Figure 12 SW10DEL SW12DEL SW16DEL Figure 13...
- Page 12 Some states do not allow the exclusion of incidental or consequential damages, so the above limitation may not apply to you. NO REPRESENTATIVE, DEALER, RECOMMENDED SERVICE CENTERS OR OTHER PERSON IS AUTHORIZED TO ASSUME FOR SUBURBAN MANUFACTURING COMPANY ANY ADDITIONAL, DIFFERENT OR OTHER LIABILITY IN CONNECTION WITH THE SALE OF THIS SUBURBAN PRODUCT.
- Page 13 D'Achat:_______________________________ Date Stock:_________________________________ Numéro www.rvcomfort.com Série:_________________________________ Numéro 7101 Ext. 775-2131, (423) 37321 Tennessee Dayton, Modéle:_________________________________ Numéro Street Broadway Department Service Customer l'appareil: descriptive l'information ci-dessous inscrire référence, Pour Company Manufacturing Suburban contactez: fournie liste vous référez proche, plus réparation service centre localiser Pour...
- Page 14 Figure SW16DEL SW12DEL SW10DEL Figure SW6DEL...
- Page 15 121577 ..........SW16DEL SW12DEL, SW10DEL, Exigees) 232948 ........................Relais 232459 ................SW16DEL représenté) (Pas électrode 232456 ......SW12DEL, SW10DEL, SW6DEL, représenté) (Pas électrode 171463 ..........................Loxit 171463 ..........................Loxit 063444 ........................Support 121943 ............. Exigées) Rondelle 232881 ................... lumineux Commutateuritémoin...
- Page 16 l'arrt. L’interrupteur réparateur. téléphoner avant vérifiés doivent suivants articles pas, s'allumera tre gaz. conduites purgé soit l'air tout avant d'allumage cycles plusieurs exiger peut chauffe-eau marche mettre premier d'allumage. cycle récommencera MARCHE". "EN position l'interrupteur tourner secondes cinq atteindre "L'ARRT", l'interrupteur...
- Page 17 pouce. vidange bouchon remplacez l’hiver) pour (l’entreposant anode tige enlevez antigel, d’elle-même. fermer doit elle soupape manette Lâcher ajoutant l’hiver pour chauffe-eau votre préparer l’intention avez vous dérivation, conduit d’un équipé n’est tuyauterie réservoir. cesse. l’écoulement à jusqu’ sédiment épais prématurée panne créant...
- Page 18 Figure (Voir à chauffe-eau votre ventouse terminer sécurité votre SW16DEL SW12DEL, SW10DEL, SW6DEL, MODÈLES: Pour chauffe-eau. votre déchargement faites être doit l'attention MANUELLE patio, porche additionnelles, chambres considérant ZÉRO À REMISE THERMOSTAT qualifiée.
- Page 19 Figure ERRATIQUE TYPE ORANGE faut. s'il Remplacer chauffe-eau. tuyaux branchements JAUNE/ JAUNE tuyaux détérioration pour annuellement inspecté être doit système moteur. fonctionnement pendant moteur, à l'aide chaleur d'échangeur travers à adéquate l’eau circulation l’eau fuites pour branchements tous Inspecter colliers. avec "Y"s moteur...
- Page 20 connections toutes pour isolées bornes l’utilisation recommandons Nous fuites! pour regarder pour ouverte flamme utiliser AVERTISsem*nT! continue surtension, toute Filtrage constante tension d’une Fourniture immédiatement. légère plus fuite même Corriger l’eau. savon solution utilisant fuites, fonctions: pour branchements raccords touts regarder Ouvrir deux...
- Page 21 Figure SW6DEL Figure SW16DEL SW12DEL SW10DEL...
- Page 22 Figure SW6DEL Figure ENVIRON. CALES UTILISER BOUGER. PUISSENT QU'ELLES POUR PLANCHER CALES FIXER CHAUFFE-EAU. CHEMISE AVEC CONTACT CÔTÉ CHAQUE CALE INSTALLER PLANCHER ENCADREMENT AVEC OUVERTURE V.R. L'INTÉRIEUR DEPUIS CHAUFFE-EAU Figure Figure 3/4"+1/8"-0" B=12 3/4"+1/8"-0" A=12 PLANCHÉIAGE EXTERNE VOITURE 3/8"±1/16" CADRAGE 3/8"±1/16"...
- Page 23 (l’ouverture voiture contrôle boîtier Fixer l'installateur. permanence monté être doit chauffe-eau. fixée n'est SW6DEL modèle module carte exterieure. voiture peau controle boitier devant jusqu’a l’ouverture dans l’unite porte. attacher pour degrés loquet Tourner Glisser illustree.
- Page 24 TÉLÉPHONE AUCUN UTILISER ÉLECTRIQUE: INTERRUPTEUR AUCUN TOUCHER • APPAREIL AUCUN D’ALLUMER ESSAYER • SENTEZ VOUS FAIRE SÉCURITÉ VOTRE POUR MOBILE LOGEMENT RÉCRÉATION VÉHICULES DANS L’INSTALLATION POUR SW16DEL • SW12DEL • SW10DEL • SW6DEL MODÈLES CHAUFFE-EAU DIRECTE VENTOUSE D’EXPLOITATION D’INSTALLATION MANUEL...
This manual is also suitable for:
Sw12delSw10delSw16del
